杰狮车故障代码表中文版-印刷

ECUABS故障代码40B01故障部件左前车轮感应器故障说明轮速传感器与齿圈间的间隙太大， 传感器输出电压太低，但刚好超过触发水平轮胎与齿圈的比率：前桥相差10%，后桥相差超过19%，检查轮胎外径和齿圈检查有直流电压，可能是短路或者蓄电池电压有阻抗检查出短路（接地）检查出断路传感器线IG和IGM之间短路 速度超过10公里/小时时，不断检测到失灵。 需要车轮转动再检查 检查出持续16秒的滑动 检测到另一个感应器的IG或IGM线车轮转速信号临时丢失。气隙过大，丢失速度信号 刹车挤压或者咔哒作响测量到不可靠的感应器频率轮速传感器与齿圈间的间隙太大， 传感器输出电压太低，但刚好超过触发水平轮胎与齿圈的比率：前桥相差10%，后桥相差超过19%，检查轮胎外径和齿圈 检查有直流电压，可能是短路或者蓄电池电压有阻抗 检查出短路（接地）检查出断路故障类别01ABS02ABSABSABSABSABS0304050607ABSABSABSABSABSABS40B02 右前车轮感应器故障080910111201ABS02ABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoD030405传感器线IG和IGM之间短06路 速度超过10公里/小时时，07不断检测到失灵。 需要些车轮转动08 检查出持续16秒的滑动 检测到另一个感应器的IG09或IGM线车轮转速信号临时丢失。10气隙过大，丢失速度信号11 刹车挤压或者咔哒作响ABS WabcoDABS WabcoDABS WabcoD40B03 左后车轮感应器故障ABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoD测量到不可靠的感应器频率轮速传感器与齿圈间的间隙太大， 传感器输出电压太低，但刚好超过触发水平轮胎与齿圈的比率：前桥相差10%，后桥相差超过19%，检查轮胎外径和齿圈 检查有直流电压，可能是短路或者蓄电池电压有阻抗 检查出短路（接地）检查出断路120102030405传感器线IG和IGM之间短06路 速度超过10公里/小时时，07不断检测到失灵。 需要些车轮转动08 检查出持续16秒的滑动 检测到另一个感应器的IG09或IGM线车轮转速信号临时丢失。10气隙过大，丢失速度信号11 刹车挤压或者咔哒作响测量到不可靠的感应器频率轮速传感器与齿圈间的间隙太大， 传感器输出电压太低，但刚好超过触发水平轮胎与齿圈的比率：前桥相差10%，后桥相差超过19%，检查轮胎外径和齿圈 检查有直流电压，可能是短路或者蓄电池电压有阻抗 检查出短路（接地）检查出断路120140B04右后车轮感应器故障02ABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoD030405传感器线IG和IGM之间短06路 速度超过10公里/小时时，07不断检测到失灵。 需要些车轮转动08 检查出持续16秒的滑动 检测到另一个感应器的IG09或IGM线ABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoD车轮转速信号临时丢失。气隙过大，丢失速度信号 刹车挤压或者咔哒作响测量到错误的感应器频率40B07左前调节器不工作发现直流电压，短路断路感应器线IG和IGM之间发现短路发现直流电压，短路断路感应器线IG和IGM之间发现短路发现直流电压，短路断路感应器线IG和IGM之间发现短路发现直流电压，短路断路1011120305060305060305060300B08右前调节器不工作40B09左后调节器不工作40B0A右后调节器不工作40B0DDBR.缓速器感应器线IG和IGM之间发06现短路发现DC电压，短路或者蓄03电池电压有阻抗05断路感应器线IG和IGM之间发现短路 发现短路（与接地端）断路060400B0EABS错误40B0F ABS错误速度超过10公里/小时时，07不断检测到失灵。 需要些车轮转速检查到直流电，短路或者03与电源连接时有阻抗04与接地点短路断路00B10 ABS错误 感应器线IG和IGM之间发06现短路速度超过10公里/小时时，07不断检测到失灵。 需要些车轮转速检查到直流电，短路或者03与电源连接时有阻抗错误

ABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoD断路40B12ABS错误检查到直流电，短路或者与电源连接时有阻抗断路050300B13ABS错误 感应器线IG和IGM之间发06现短路检查到直流电，短路或者03与电源连接时有阻抗05发现开路 IG和IGM感应线之间发现06短路08 发现开路里程表车速和ABS车速两者不匹配SAE J1939无法数据交互高SAE J1939开路或与正极或是地线短路；低SAEJ1939或低/高被误用SAE J1939 通讯无效SAE J1939断路缓速器发送信息错误。 激活时检测到暂停监控错误缓速器发送信息错误。激活时检测到暂停监控错误变速器发送数据错误激活时检测到暂停监控错误 发动机控制发送扭矩信息错误检测到暂停监控错误缓速器发送信息错误。 激活时检测到暂停监控错误内部错误 供电电压过高超过5秒轮胎参数超过公差. 没有ABS，ASR，EBL，SM参数校验或者类似的调整错误没有调节器连接050200B10B1740BE7ABS错误ABS错误ABS错误. SAE J1939ABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoDABS WabcoD0607080909101203021200BFB40BFDABS错误. 超电压ABS错误40BFEABS错误 车辆的一个桥比其它桥速08度快通过调节器进行的控制过09长。 延迟一段时间后功能正常。ABS WabcoDBC IBC2BC IBC2内部错误2210122102EEPROM 校验和错误 ECU过热1212车身电脑内存出错 输出驱动的连接处温度高12于最大的温度值（150度）BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC222103221042210522106221072210822109BC IBC2BC IBC2BC IBC22210A2210B2210CBC IBC2BC IBC2BC IBC2BC IBC2BC IBC22210D2210E2210F2211022111BC IBC2BC IBC22211222113要求的电压低于或高过初0001始值。0304电源电路2要求的电压低于或高过初0001始值。0304电源电路3要求的电压低于或高过初0001始值。0304电源电路4要求的电压低于或高过初0001始值。0304电源电路5要求的电压低于或高过初0001始值。0304 右转向灯要求的负载电流低于额定05值（三个灯泡至少有一个开路）拖车右转向灯 开/关诊断。 只有停车时05才可以进行测试。 只有开路的时候才能检测到错误。右转向灯或拖车右转向灯检查到有短路、接地、超06负荷、过热故障。05 左转向灯电压过低 拖车左转向灯 开/关诊断。 只有停车时05才可以进行测试。 只有开路的时候才能检测到错误。左转向灯或拖车左转向灯检查到有短路、接地、超06负荷、过热故障。左停车& 右前信号灯要求的负载电流低于临界05值（至少一个断路）右后停车灯 要求的负载电流低于临界05值（至少一个断路）牌照灯要求的负载电流低于临界05值（至少一个断路）06左停车&右前信号灯 或者电压过低右后停车灯 或者 牌照灯或者挂车灯后停车&左前信号灯要求的负载电流低于临界05值（三个中至少一个断路）左后停车灯要求的负载电流低于临界05值（三个中至少一个断路）电源电路1BC IBC2BC IBC22211422115后信号灯BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2221162211722118221192211A2211BBC IBC2BC IBC2BC IBC2BC IBC22211C2211D2211E2211FBC IBC2BC IBC2BC IBC2BC IBC2要求的负载电流低于临界值（三个中至少一个断路）s右停车&左前信号灯 或者电压过低，左后停车灯 或者后信号灯或者 停车&拖车信号&左侧信号灯左后和右后雾灯要求的负载电流低于临界值（两个中至少一个断路）左&右后雾灯或者拖车左&检查到有短路、接地、超负荷、过热故障。右后雾灯左后停车灯要求的负载电流低于临界值（唯一的负载开路）右后停车灯要求的负载电流低于临界值（唯一的负载开路） 左停车灯或者右停车灯或检查到有短路、接地、超负荷、过热故障。者拖车左右停车灯转向灯开关左转和右转开关同时被通电。 CAN't线左转向灯和右转向灯状态参数是“开”但是CAN't线紧急灯状态是“关” 风挡雨刮器供电电路6故障、电机卡滞、短路、接地发动机制动预选模式开关发动机制动模式下加速器怠速和制动踏板开关同时被激活差速锁开关差速锁开关同时打开 前制动气压感应器 要求电压低于或高于临界值只有在感应器的供电电压没有错误时才会发现错误感应器的输出电压；Vc：感应器的供电电压；Bar：大气压力05060506050506020202020022120BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC2BC IBC22212B2212B2212B2212B2212C2212D221302213022131010304 后制动气压传感器 要求电压低于或高于临界00值只有在感应器的供电电压没有错误时才会发现错误感应器的输出电压；Vc：感应器的供电电压；Bar：0103大气压力0400 (Vc) 制动气压传感器电源电压过低或过高010304023103040304CAN整车数据总线CAN没有CAN信号，只有重新加载CAN时才能读本信号 ECU未编程发动机起动机电压过高或短路Engine Starter电压过高或短路驾驶室内白顶灯（只在E03电压过高或短路的针脚）电压过高或短路IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E421701217042170521706 EEPROM校验总值步进电机 燃油液面传感器机油液面传感器IC内存错误后检查出校验总值仪表的电机出错电压过高或过低电压过高或过低1212030001030415161718192021707 环境温度感应器IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E4IC SPR1 E42170C2170D2170E2170F21710217112171221713车辆数据总线 CAN车辆数据总线 -ECU#1CAN车辆数据总线 -ECU#2CAN车辆数据总线 -ECU#3CAN车辆数据总线 -ECU#4CAN车辆数据总线 -ECU#5CAN车辆数据总线 -ECU#6CAN车辆数据总线 -ECU#7CAN车辆数据总线 -ECU#8CAN车辆数据总线 -ECU#9CAN加速踏板1故障IC SPR1 E4IC SPR1 E4ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31217142171510012 检测到环境温度界面错误。 反跳时间（错误出现和不出现状态）是4秒。输入电压用于评估范围内的检查无CAN信号IBC 接收不到从ECU#1 -车身电脑来的CAN信号 接收不到从ECU#2-电控喷油装置来的CAN信号 接收不到从ECU#3-TCO来的CAN信号 接收不到从ECU#4 - ETC来的CAN信号 接收不到从 ECU#5 - EBC来的CAN信号 接收不到从 ECU#6 -ECAS来的CAN信号接收不到从ECU#7 -动力传动系统缓速器来的CAN信号 接收不到从ECU#8 -电控后视镜来的CAN信号接收不到从ECU#8 -膨胀模块来的CAN信号APP10304020202020202020202020304021210013 加速踏板/制动可靠性AccPedPlausBrk12ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31100161001610017100171001920011200112001120011200153001510025主离合器信号错误Main clutch signal制动信号错误Brake signal failure终端15故障车速传感器错误ConvCDConvCDBrkCDBrkCDT15CDVSSCD20212021202030402121212Vehicle Speed SensorVSSCD2failureVehicle Speed SensorVSSCD2failureVehicle Speed SensorVSSCD2failure 巡航控制按钮不可逆错误MFLv_Irvrs巡航控制按钮可逆错误MFLv_Rvrs主继电器2错误（栅格加热MRlyCD器1，风扇1，VGT，Lambda加热器，EGR件，曲轴箱通风阀） 蓄电池电压故障Battery voltage fault发动机制动解压阀EnBattCDBattCDCRERCDCRERCD030403040304030304100261002610027100271002810029100291002A1002A1002B1002B1002B1002E20025 主继电器1（高压泵）与MnRly1_SCB蓄电池短接主继电器3（A/C 压缩/燃油MRlyCDMnRly3过滤器加热）主继电器4(排气阀发动机制动拍打)Main relay 4 (Exhaustvalve eng.brake flap)空气加热器１的驱动器故障EVCDEVCDArHt10304030402空气加热器始终打开主继电器故障（启动后阻断）AirHtStickOnIvMRlyCDAftRun0303ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC312002810031100311003110031100321003310033100331003410034100341003410035100351003610036100371003710037100381003810038100381003A1003A1003AMnRly1_SCG主继电器SCGND（Lambda加热气／栅格加热器／电池开关）CTSCD冷却液温度传感器0403040212冷却液温度传感器动态测试增压气体温度传感器错误Clg_DynTstIATSCD12030402增压压力传感器BPSCD03040212 燃油温度传感器错误FTSCD03040304030402Fuel Temperature SensorFTSCDfailureRailCD轨压传感器CP3Rail pressure sensor CP3RailCD共轨压力阀错误PRVMon机油压力传感器错误OPSCD03040212机油温度传感器Oil Temp. SensorOil Temp. SensorOTSCDOTSCDOTSCD030402ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC311003A20032 冷却液温度传感器完全测ClgAbsTst试 共轨压力传感器RailCDOfsTst12122003620036200382003A1004110041100421004310043100441004A2004A1004D1005B2009D0304 机油压力过低 机油温度高过正常值曲轴传感器错误OPSCD1OTSCD1EngMCrS112120204030204030202030304Crankshaft sensor failureEngMCrS2只有凸轮轴传感器运行凸轮轴速度传感器错误Camshaft sensor failure凸轮轴和曲轴之间信号抵消发动机副起动按钮发动机副熄火按钮发动机超速保护高压测试（轨压监测无效）Torque Limitation due toNegative TorqueCoordinator 负扭矩等效器导致的扭矩由于涡轮增压器保护导致扭矩极限由于发动机保护（由于过度扭矩，发动机超速和过热）导致的扭矩极限 由于喷油系统错误导致燃油量变化，导致的扭矩极限轨道压力正偏差过大和燃油流量设定值过高最小测定时共轨压力负偏差过高在控制状态下共轨压力低于最小轨压在控制模式下高于最大限值轨压下降斜率高于预测值EngMBackUpEngMCaS1EngMCaS2EngMOfsCaSCrSECBtCDStartECBtCDStopEngPrtOvrSpdHpTstNTCTrqLimECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC313009E4009E6009EBstPrtTrqLimEngPrtTrqLimQLimTrqLim04040410052100531001005510056RailMeUn1RailMeUn2RailMeUn3RailMeUn4RailMeUn60303030303ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31100571005810059100592005930059100611006110061100611006210062100621006210063100631006310063100100100100100651006510065100651006610066共轨监控单元设定的值在超出限度时不可靠共轨监控单元的燃油流量设定值过低 共轨油压计量单元故障Common Rail MeteringUnit Power Stage failure共轨油压计量单元与电源短接共轨油压计量单元与地线短接汽缸1喷油器错误Injector Cylinder 1 failureInjector Cylinder 1 failureInjector Cylinder 1 failure汽缸2喷油嘴错误Injector Cylinder 2 failureInjector Cylinder 2 failureInjector Cylinder 2 failure汽缸3喷油嘴错误Injector Cylinder 3 failureInjector Cylinder 3 failureInjector Cylinder 3 failure汽缸4喷油嘴错误Injector Cylinder 4 failureInjector Cylinder 4 failureInjector Cylinder 4 failure汽缸5喷油嘴错误Injector Cylinder 5 failureInjector Cylinder 5 failureInjector Cylinder 5 failure汽缸6喷油嘴错误Injector Cylinder 6 failureRailMeUn7RailMeUn10MeUnCDNoLoadMeUnCDNoLoadMeUnCDSCBatMeUnCDSCGndInjVlvCyl1AInjVlvCyl1AInjVlvCyl1AInjVlvCyl1AInjVlvCyl2AInjVlvCyl2AInjVlvCyl2AInjVlvCyl2AInjVlvCyl3AInjVlvCyl3AInjVlvCyl3AInjVlvCyl3AInjVlvCyl4AInjVlvCyl4AInjVlvCyl4AInjVlvCyl4AInjVlvCyl5AInjVlvCyl5AInjVlvCyl5AInjVlvCyl5AInjVlvCyl6AInjVlvCyl6A03030212030403040212030402120304021203040212030402120304ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC3110066100661006710067100671006710068100681006810068100691006910069100691006A1006A1006A1006A1006B1006B1006B1006B1006C1006C1006C1006C1006E10071Injector Cylinder 6 failureInjector Cylinder 6 failure汽缸1喷油嘴警告Injector Cylinder 1warningInjector Cylinder 1warningInjector Cylinder 1warning汽缸2喷油嘴警告InjVlvCyl6AInjVlvCyl6AInjVlvCyl1BInjVlvCyl1BInjVlvCyl1BInjVlvCyl1BInjVlvCyl2B02120304021203040212汽缸3喷油嘴警告Injector Cylinder 3warningInjector Cylinder 3warningInjector Cylinder 3warning汽缸4喷油嘴警告Injector Cylinder 4warningInjector Cylinder 4warningInjector Cylinder 4warning汽缸5喷油嘴警告Injector Cylinder 5warningInjector Cylinder 5warningInjector Cylinder 5warning汽缸6喷油嘴警告Injector Cylinder 6warningInjector Cylinder 6warningInjector Cylinder 6warning未达到最低喷射量喷油器密闭腔1故障InjVlvCyl3BInjVlvCyl3BInjVlvCyl3BInjVlvCyl3BInjVlvCyl4BInjVlvCyl4BInjVlvCyl4BInjVlvCyl4BInjVlvCyl5BInjVlvCyl5BInjVlvCyl5BInjVlvCyl5BInjVlvCyl6BInjVlvCyl6BInjVlvCyl6BInjVlvCyl6BInjVlvNumMinInjInjVlvBnk1A030402120304021203040212030402120303ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31100711007110071100731007310073100731007C1007C1007C1007C2007C2007C2007C2007C1009E100B1100B2100B3100B4100B7200B4100C3100D1100D2100D2Bank 1 specific errors -Short circuit / notclassifyableBank 1 specific errors -Short circuit / notclassifyableBank 1 specific errors -Short circuit / notclassifyable喷油器密闭腔2故障InjVlvBnk1A04InjVlvBnk1A02InjVlvBnk1A12InjVlvBnk2A03040212ECU喷油硬件：CY33X模块特殊故障(1)Chip-specific errors-->stop engineChip-specific errors-->stop engineChip-specific errors-->stop engineECU喷油硬件：CY33X模块特殊故障(2)Chip-specific errors-->stop engineChip-specific errors-->stop engineChip-specific errors-->stop engine烟雾导致的扭矩减小CAN A与CANA总线传输中断CAN B与CANB总线传输中断CAN C与CANC总线传输中断BC-EDC信号超时 CAN传输信号超时BC-EDC2信号超时TCO--CAN信息TCO1超时ECU硬件SPI通信故障ECU硬件：EEPROM故障InjVlvChipAInjVlvChipAInjVlvChipAInjVlvChipAInjVlvChipBInjVlvChipBInjVlvChipBInjVlvChipBSmkTrqLimNetMngCANAOffNetMngCANBOffNetMngCANCOffFrmMngTOBC2EDC1IvFrmMngTxTOFrmMngTOBC2EDC2IvFrmMngTOTCO1HWEMonComHWEMonEEPROM03040212030402120403030302020202030402ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31100D2100D3100D4100D5100D5100D5100D6100D7100D7100D8100D9100D9100D9100D9200D3300D3100E1100E1 ECU硬件：TPU监控ECU软件：变量数据设定故障ECU Software: VariantDataset failureECU硬件：控制看门狗故障 ADC监控故障ADC Monitoring failureADC Monitoring failureADC Monitoring failureECU解除锁定—被抑制ECU锁定解除-可见的 ECU硬件：接地短路或断电ECU Hardware: High SidePower Stage Short toGround or Battery防盗器故障（没有燃油释放）Overrun Monitoring failure超限监控故障发动机超速TPUMonVarMngCodDsVarMngCodDsWdComADCMonADCMonADCMonADCMonECU 锁定解除-ECU锁定HWEMonRcyLocked1212120402121202121203040212 ECU硬件：微控制器看门Montr狗故障ECU硬件：初始化时中断SOPTstHWEMonRcySuppressed12HWEMonRcyVisibleStrtCDHSStrtCDHS120304100E2100E3100E4100E5100E5ImmCtlOvRMonOvRMonSigA0403030304 ECU 硬件：传感器 12VSSpMon12V供应电压故障ECU Hardware: SensorSSpMon12V12V Supply Voltage failure ECU 硬件：传感器供应电压1故障ECU Hardware: SensorSupply Voltage 1 failureECU 硬件：传感器供应电压2故障ECU Hardware: SensorSupply Voltage 2 failureSSpMon1SSpMon1SSpMon2SSpMon2100E6100E6100E7100E703040304ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31ECMEDCUC31WeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichai985985520192520192520192520192172172132100E8100E8100E9100EA100EB100EB100EB100EBECU 硬件：传感器供应电SSpMon3压3故障ECU Hardware: SensorSSpMon3Supply Voltage 3 failureHWEMonUMaxSupplyECU内部电压供应过高ECU内部电压供应过低气压传感器Atmospheric PressureSensorAtmospheric PressureSensorAtmospheric PressureSensorECU硬件：接地短路或与电源短接ECU Hardware: Low SidePower Stage Short toGround or BatteryECU Hardware: Low SidePower Stage Short toGround or BatteryDfp_ACCDSwtin空压机开关故障Dfp_ACCDSwtin空压机开关故障Dfp_ADCMon模数转换器故障Dfp_ADCMon模数转换器故障Dfp_ADCMon模数转换器故障Dfp_ADCMon模数转换器故障Dfp_AFSCD_AirTempHFM传感器故障Dfp_AFSCD_AirTempHFM传感器故障Dfp_AFSCD_PlOffsDrftHFM传感器漂移故障Dfp_AFSCD_PlOffsDrftHFM传感器漂移故障Dfp_AFSCD_PlSetyDrft空气流量比故障Dfp_AFSCD_PlSetyDrft空气流量比故障Dfp_AFSCD_SRCAirm空气流量故障HWEMonUMinSupplyAPSCDAPSCDAPSCDAPSCD0304030403040212200E1200E1StrtCDLSStrtCDLS0304200E1StrtCDLS02003D9003D97F0007F0007F0007F000000AC000AC00084Weichai13200084Weichai5201937F001Weichai5201937F001Weichai13200084Fault path of air conditionpower stageFault path of air conditionpower stageError status of ADCmonitoringError status of ADCmonitoringError status of ADCmonitoringError status of ADCmonitoringIntake Air TemperaturesensorIntake Air Temperaturesensorerror path for plausibilitycheck of offset drift ofairmasserror path for plausibilitycheck of offset drift ofairmassfault path for plausibilitycheck of sensitivity drift ofairmassfault path for plausibilitycheck of sensitivity drift ofairmasserror path for signal rangecheck of airmass12020304110203040304030403WeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichai132919191292929108000840005B0005B0005B0001D0001D0001D0006CDfp_AFSCD_SRCAirm空气流量故障Dfp_APP1油门踏板1故障Dfp_APP1油门踏板1故障Dfp_APP1油门踏板1故障Dfp_APP2油门踏板2故障Dfp_APP2油门踏板2故障Dfp_APP2油门踏板2故障Dfp_APSCD大气压力传感器故障Dfp_APSCD大气压力传感器故障Dfp_APSCD大气压力传感器故障Dfp_APSCD大气压力传感器故障Dfp_ASLLCD车速指示灯故障Dfp_ASLLCD车速指示灯故障Dfp_ASLLCD车速指示灯故障Dfp_ASLLCD车速指示灯故障Dfp_AccPedPlausBrkDfp_AirCtlGvnrDvtMaxDfp_AirCtlGvnrDvtMinDfp_AirHtStickOnDfp_AirHt_Test1进气加热器电压故障1Dfp_AirHt_Test1进气加热器电压故障1Dfp_AirHt_Test2进气加热器故障电压2Dfp_AirHt_Test2进气加热器故障电压2Dfp_ArHt1进气加热器故障Dfp_ArHt1进气加热器故障WeichaiWeichaiWeichaiWeichai1081081085201940006C0006C0006C7F002Weichai5201947F002Weichai5201947F002Weichai5201947F002WeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichai915201955201966767297297307307297290005B7F0037F004002A4002D9002D9002DA002DA002D9002D9error path for signal rangecheck of airmassfault path of AccleratorPedal 1fault path of AccleratorPedal 1fault path of AccleratorPedal 1fault path of AcceleratorPedal 2fault path of AcceleratorPedal 2fault path of AcceleratorPedal 2error path of atmosphericpressure sensor 气压感应器故障error path of atmosphericpressure sensorerror path of atmosphericpressure sensorerror path of atmosphericpressure sensorError path for theAdjustable Speed LimitlampError path for theAdjustable Speed LimitlampError path for theAdjustable Speed LimitlampError path for theAdjustable Speed LimitlampError path for AccPed andBrake PlausibilityAirCtl permanent positivegovernor deviationAirCtl permanent negativegovernor deviationGrid heaters alwaysswitched onfault path1 of air heatertestswitch onfault path1 of air heatertestswitch onfault path2 of air heatertestswitch offfault path2 of air heatertestswitch offerror path of power stageair heater 1 actuatorerror path of power stageair heater 1 actuator04030402030402030412020304050207151707030403040304Weichai1192004A8Dfp_BPACD_MaxWeichai1192004A8Dfp_BPACD_MinDfp_BPACD_SigNpl增压器信号故障Dfp_BPACD_SigNpl增压器信号故障Dfp_BPSCD进气压力传感器故障Dfp_BPSCD进气压力传感器故障Dfp_BPSCD进气压力传感器故障Dfp_BPSCD进气压力传感器故障Dfp_BattCD电池电压故障Dfp_BattCD电池电压故障Dfp_BrkCD刹车信号故障Dfp_BrkCD刹车信号故障Dfp_CABCD中冷器旁通阀故障Dfp_CABCD中冷器旁通阀故障Dfp_CABCD中冷器旁通阀故障Dfp_CLSCD冷却水水位传感器故障Dfp_CLSCD冷却水水位传感器故障Dfp_CLSCD冷却水水位传感器故障Dfp_CLSCD冷却水水位传感器故障Dfp_CRERCD_ActrCRERCD故障Dfp_CRERCD_ActrCRERCD故障Dfp_CRERCD_ActrCRERCD故障Dfp_CRERCD_ActrCRERCD故障Dfp_CSLpCD冷启动指示灯故障Weichai1192004A8Weichai1192004A8WeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichai10210210210216816859759752019700066000660006600066000A8000A800255002557F005fault path for short circuitto battery for BPA powerstagefault path for short circuitto ground for BPA powerstagefault path for no load andexcess temparature forBPA power stagefault path for no load andexcess temparature forBPA power stageError path for boostpressure sensorError path for boostpressure sensorError path for boostpressure sensorError path for boostpressure sensorbattery voltage fault 电池电压故障battery voltage fault03041202030412020304Error path for brake signal12刹车信号故障Error path for brake signal02刹车信号故障03error path of IntercoolerBypass Valve Powerstageerror path of IntercoolerBypass Valve Powerstage04Weichai5201977F005Weichai5201977F005error path of Intercooler12Bypass Valve Powerstageerror path for coolant levelsensorerror path for coolant levelsensorerror path for coolant levelsensorerror path for coolant levelsensorFault path of CRERCDcondition power stageFault path of CRERCDcondition power stageFault path of CRERCDcondition power stageFault path of CRERCDcondition power stageError path for the coldstart lamp 冷启动灯路径错误03041202030425525503WeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichai111111111111107210721072107210810006F0006F0006F0006F0043000430004300043000439WeichaiWeichaiWeichaiWeichai1081108110811100043900439004390006EWeichai1100006EWeichai1100006EWeichai1100006EDfp_CSLpCD冷启动指示灯故障Dfp_CSLpCD冷启动指示灯故障Dfp_CSLpCD冷启动指示灯故障Dfp_CTSCD冷却水温度传感器电压信号故障Dfp_CTSCD冷却水温度传感器电压信号故障Dfp_CTSCD冷却水温度传感器电压信号故障Dfp_CTSCD冷却水温度传感器电压信号故障Dfp_ClgAbsTstDfp_Clg_DynTstDfp_CmbChbMisfire1Dfp_CmbChbMisfire2Dfp_CmbChbMisfire3Dfp_CmbChbMisfire4Dfp_CmbChbMisfire5Dfp_CmbChbMisfire6Dfp_CmbChbMisfireMulDfp_CoVMDCShDfp_ComprTstDfp_ConvCD离合器状态信号错误Dfp_ConvCD离合器状态信号错误Dfp_EATSCD环境温度传感器故障Dfp_EATSCD环境温度传感器故障Dfp_EATSCD环境温度传感器故障Dfp_EATSCDBET环境温度传感器BET电压故障Error path for the coldstart lampError path for the coldstart lampError path for the coldstart lamperror path of coolanttemperature sensorerror path of coolanttemperature sensorerror path of coolanttemperature sensorerror path of coolanttemperature sensorCoolant temperaturesensor absolute testCoolant temperaturesensor dynamic testerror path for Misfirecylinder 1error path for Misfirecylinder 2error path for Misfirecylinder 3error path for Misfirecylinder 4error path for Misfirecylinder 5error path for Misfirecylinder 6error path for misfire inmultiple cylindersphysical plausibility DCSfaultpath for compressiontestdiagnostic fault pathsignals errors of mainclutch signaldiagnostic fault pathsignals errors of mainclutch signalerror path of environmentair temperature sensorerror path of environmentair temperature sensorerror path of environmentair temperature sensorerror path of BETtemperature sensor04120203041202WeichaiWeichai5201985201987F0067F0060202WeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichai13231324132513261327132813225201995202005980052B0052C0052D0052E0052F005300052A7F0077F008002560303030303030302201202Weichai59800256WeichaiWeichaiWeichaiWeichai171171171520201000AB000AB000AB7F00903041203Weichai5202017F009Weichai5202027F00AWeichai5202027F00AWeichai5202037F00BWeichai5202037F00BDfp_EATSCDBET环境温度传感器BET电压故障Dfp_EATSCDClgZn环境温度传感器CLgZn电压故障Dfp_EATSCDClgZn环境温度传感器CLgZn电压故障Dfp_EATSCDInAir环境温度传感器InAir电压故障Dfp_EATSCDInAir环境温度传感器InAir电压故障Dfp_EBSwPreSelPlausDfp_ECBCDEGR旁通阀故障Dfp_ECBCDEGR旁通阀故障Dfp_ECBCDEGR旁通阀故障Dfp_ECBtCDDfp_EGPpCDP3排气管压力传感器故障Dfp_EGPpCDP3排气管压力传感器故障Dfp_EGPpCDP3排气管压力传感器故障Dfp_EGRCD_Maxerror path of BETtemperature sensorerror path of ClgZntemperature sensorerror path of ClgZntemperature sensorerror path of Inside airtemperature sensor 内部空气温度感应器路径错误error path of Inside airtemperature sensor 内部空气温度感应器路径错误fault path for EngineBrake Pre-Selectionswitch statuserror path of power stagefor EGR Bypass valveactuatorerror path of power stagefor EGR Bypass valveactuatorerror path of power stagefor EGR Bypass valveactuatorfault path 1 for EngineCompartment Start ButtonError path for ExhaustGas Pipe PressureSensorError path for ExhaustGas Pipe PressureSensorError path for ExhaustGas Pipe PressureSensorfault path for short circuitto battery for EGR powerstagefault path for short circuitto ground for EGR powerstagefault path for no load andexcess temparature forEGR power stagefault path for no load andexcess temparature forEGR power stageif running with cam-shaftonly is active the fault pathis seterror path of camshaftfailure0403040304Weichai5202047F00C02Weichai5202057F00D03Weichai5202057F00D04Weichai5202057F00D1208Weichai104100411Weichai5202067F00E03Weichai5202067F00E04Weichai5202067F00E02Weichai279100AE703Weichai279100AE7Dfp_EGRCD_Min04Weichai279100AE7Dfp_EGRCD_SigNpl05Weichai279100AE7Dfp_EGRCD_SigNpl02Weichai190000BEDfp_EngMBackUpDfp_EngMCaS1凸轮轴信号故障1212Weichai6360027CWeichaiWeichaiWeichaiWeichai6361901901900027C000BE000BE000BEDfp_EngMCaS1凸轮轴信号故障Dfp_EngMCrS1曲轴信号故障Dfp_EngMCrS1曲轴信号故障WeichaiWeichai53310740021500432Weichai107400432Weichai107400432Weichai107400432Weichai5202367F02CWeichaiWeichaiWeichai1741741071000AE000AE0042Ferror path of camshaftfailureerror path of crankshaftfailureerror path of crankshaftfailureerror path of offsetDfp_EngMOfsCaSCrSbetween camshaft andcrankshaftFault path of engineDfp_EngPrtOvrSpdProtectionerror path for Short circuitDfp_ExFlCD_Maxto Batt of power stage forExhaust Flap actuatorerror path Short circuit toDfp_ExFlCD_MinGround of power stage forExhaust Flap actuatorerror path for Open circuitDfp_ExFlCD_SigNpland excess temeprature排气制动蝶阀故障of Exhaust Flap actuatorerror path for Open circuitDfp_ExFlCD_SigNpland excess temeprature排气制动蝶阀故障of Exhaust Flap actuatorfaultDfp_FMTC_NonMonotonFMTC_trq2qBas_MAPMapcontaines non strictlymonotonus q curvesDfp_FTSCDFaultPath for FuelTemperature sensor燃油温度传感器故障Dfp_FTSCDFaultPath for FuelTemperature sensor燃油温度传感器故障Dfp_FanCDerror path of power stage风扇执行器PWM信号故障fan actuatorDfp_FanCDerror path of power stage风扇执行器PWM信号故障fan actuator11121107150304120213030403Weichai10710042F04Weichai10710042FDfp_FanCDerror path of power stage12风扇执行器PWM信号故障fan actuatorDfp_FanCDerror path of power stage风扇执行器PWM信号故障fan actuatorDfp_FanCD2风扇执行器数字信号故障Dfp_FanCD2风扇执行器数字信号故障Dfp_FanCDEval冷却风扇速度故障Dfp_FanCDEval冷却风扇速度故障Dfp_FlFCD_FltFoulMaxDfp_FlFCD_FltFoulMinerror path of power stagefan 2 actuatorerror path of power stagefan 2 actuatorerror path of fan speedsensor signalerror path of fan speedsensor signalFuel filter fouling switchFuel filter fouling switch02Weichai10710042FWeichaiWeichaiWeichaiWeichaiWeichaiWeichai107110711639163995950042F0042F00667006670005F0005F030403040304WeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichai95520207520207979795975202085202085202085202085202090005F7F00F7F00F00061000610005F000617F0107F0107F0107F0107F011Dfp_FlFCD_FltFoulNplDfp_FlFCD_Htg燃油滤清器加热器故障Dfp_FlFCD_Htg燃油滤清器加热器故障Dfp_FlFCD_WtLvlMaxDfp_FlFCD_WtLvlMinDfp_FlSys_FltFoulDfp_FlSys_WtDetDfp_FrmMngEngGsFlRtHtrDfp_FrmMngEngGsFlRtHtrDfp_FrmMngEngGsFlRtHtrDfp_FrmMngEngGsFlRtHtrDfp_FrmMngRxEngTmp2SensDfp_FrmMngRxEngTmp2SensDfp_FrmMngRxEngTmp2SensDfp_FrmMngRxEngTmp2SensDfp_FrmMngTODashDsplDfp_FrmMngTOEBC1Dfp_FrmMngTOERC1DRDfp_FrmMngTOETC1Dfp_FrmMngTOEngGsFlowRtDfp_FrmMngTOHRVDDfp_FrmMngTORxAMCONDfp_FrmMngTORxCCVSDfp_FrmMngTORxEngTemp2Dfp_FrmMngTOTCO1Dfp_FrmMngTOTFDfp_FrmMngTOTSC1AEFuel filter fouling switchFault path for fuel filterheating outputFault path for fuel filterheating outputWater in fuel sensorWater in fuel sensorFuel filter fouling detectionDfp for Water DetectionSensorDfp for Heater used inEGR Mass Flow rateDfp for Heater used inEGR Mass Flow rateDfp for Heater used inEGR Mass Flow rateDfp for Heater used inEGR Mass Flow rateDfp for RecirculatedEngine Exhaust GasTemperature sensorDfp for RecirculatedEngine Exhaust GasTemperature sensorDfp for RecirculatedEngine Exhaust GasTemperature sensorDfp for RecirculatedEngine Exhaust GasTemperature sensorDfp for messageDashDsplFaults of CAN messageEBC1Dfp for messageERC1DRFaults of CAN messageETC1Dfp for CAN messageEngGsFlowRtDfp timeout for messageHRVDDf p for messageRxAMCONDfp for Time-out error ofRxCCVS messageDfp for CAN messageRxEngTemp2Faults of CAN messageTCO1Dfp for message TFDfp for messages TSC1-AE020304030407110304120203Weichai5202097F01104Weichai5202097F0111202Weichai5202097F011WeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichai5202105202115202125202135202145202155202165232185236045232225202175236057F0127F0137F0147F0157F0167F0177F0187FBD27FD7FBD67F0197FD55031203121203031212120311WeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichai523605523606523606523607523607523608523608520218520218885205205202195202195202205202205202375202385235005202216246246246246246246247FD557FD567FD567FD577FD577FD587FD587F01A7F01A003820038200208002087F01B7F01B7F01C7F01C7F02D7F02E7FCEC7F01D00270002700027000270002700027000270Dfp_FrmMngTOTSC1AEDfp_FrmMngTOTSC1ARDfp_FrmMngTOTSC1ARDfp_FrmMngTOTSC1DEDfp_FrmMngTOTSC1DEDfp_FrmMngTOTSC1DRDfp_FrmMngTOTSC1DRDfp_FrmMngTOTSC1PEDfp_FrmMngTOTSC1PEDfp_FrmMngTOTSC1TEDfp_FrmMngTOTSC1TEDfp_FrmMngTOTSC1TRDfp_FrmMngTOTSC1TRDfp_FrmMngTOTSC1VEDfp_FrmMngTOTSC1VEDfp_FrmMngTOTSC1VRDfp_FrmMngTOTSC1VRDfp_FrmMngTOTimeDateDfp_FrmMngTOWSIDfp_FrmMngTxTODfp_GearbxIncMaxDfp_Gen1指示灯1故障Dfp_Gen1指示灯1故障Dfp_Gen1指示灯1故障Dfp_Gen1指示灯1故障Dfp_Gen2指示灯2故障Dfp_Gen2指示灯2故障Dfp_Gen2指示灯2故障Dfp for messages TSC1-AEDfp for message TSC1-ARDfp for message TSC1-ARDfp for messages TSC1-DEDfp for messages TSC1-DEDfp for message TSC1-DRDfp for message TSC1-DRDfp for message TSC1-PEDfp for message TSC1-PEDfp for messages TSC1-TEDfp for messages TSC1-TEDfp for message TSC1-TRDfp for message TSC1-TRDfp for messages TSC1-VEDfp for messages TSC1-VEDfp for message TSC1-VRDfp for message TSC1-VRDfp timeout for messageTimeDateFaults of CAN messageWSIFaults in CAN sendmessagesphysical plausibility TSCPower Stage fault statusfor Generic Lamp 1Power Stage fault statusfor Generic Lamp 1Power Stage fault statusfor Generic Lamp 1Power Stage fault statusfor Generic Lamp 1Power Stage fault statusfor Generic Lamp 2Power Stage fault statusfor Generic Lamp 2Power Stage fault statusfor Generic Lamp 212111211121112030411121112031203120312120203041202030412WeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichai62462462462462452361763063063063052022252022252022252361252361252022452022410510510552022552022552022552335000270002700027000270002707FD61002760027600276002767F01E7F01E7F01E7FD5C7FD5C7F0207F0200006900069000697F0217F0217F0217FC56Dfp_Gen2指示灯2故障Dfp_Gen3指示灯3故障Dfp_Gen3指示灯3故障Dfp_Gen3指示灯3故障Dfp_Gen3指示灯3故障Dfp_HWEMonComDfp_HWEMonEEPROMEEPROM错误Dfp_HWEMonEEPROMEEPROM错误Dfp_HWEMonEEPROMEEPROM错误Dfp_HWEMonEEPROMEEPROM错误Dfp_HWEMonRcyLockedPower Stage fault statusfor Generic Lamp 2Power Stage fault statusfor Generic Lamp 3Power Stage fault statusfor Generic Lamp 3Power Stage fault statusfor Generic Lamp 3Power Stage fault statusfor Generic Lamp 3error state communication- SPIerror state of EEPROMerror state of EEPROMerror state of EEPROMEEPROM使用替代值020304120211041202error path for Recoverywhich is lockedDfp_HWEMonRcySuppreerror path for Recoveryssedwhich is suppressederror path for RecoveryDfp_HWEMonRcyVisiblewhich is visibleDfp_HWEMonUMaxSupplerror state supply voltageyCJ940 upper limitDfp_HWEMonUMinSupplerror state supply voltageyCJ940 lower limitDfp_IAHSCDerror path of air humiditysensor空气湿度传感器故障Dfp_IAHSCDerror path of air humiditysensor空气湿度传感器故障Dfp_IATSCDerror path of airtemperature sensor进气温度传感器Dfp_IATSCDerror path of airtemperature sensor进气温度传感器Dfp_IATSCDerror path of airtemperature sensor进气温度传感器Dfp_InjCrv_InjLimFault path of injectionlimitation理想喷油次数受Dfp_InjCrv_InjLimFault path of injectionlimitation理想喷油次数受Dfp_InjCrv_InjLimFault path of injectionlimitation理想喷油次数受Dfp_InjVlvBnk1Afaultpath bank1-specific1、2、3缸中某喷油器短路errors -> stop engineDfp_InjVlvBnk1Afaultpath bank1-specific1、2、3缸中某喷油器短路errors -> stop engineDfp_InjVlvBnk1Afaultpath bank1-specific1、2、3缸中某喷油器短路errors -> stop engine1414140304030403041216151103Weichai5233507FC5604Weichai5233507FC5611Weichai5233507FC56Dfp_InjVlvBnk1Afaultpath bank1-specific1、2、3缸中某喷油器短路errors -> stop engineDfp_InjVlvBnk1Bfaultpath bank1-specific1、2、3缸中某喷油器断路warnings -> stop engineDfp_InjVlvBnk1Bfaultpath bank1-specific1、2、3缸中某喷油器断路warnings -> stop engineDfp_InjVlvBnk1Bfaultpath bank1-specific1、2、3缸中某喷油器断路warnings -> stop engineDfp_InjVlvBnk1Bfaultpath bank1-specific1、2、3缸中某喷油器断路warnings -> stop engineDfp_InjVlvBnk2Afaultpath bank2-specific4、5、6缸中某喷油器短路errors -> stop engineDfp_InjVlvBnk2Afaultpath bank2-specific4、5、6缸中某喷油器短路errors -> stop engineDfp_InjVlvBnk2Afaultpath bank2-specific4、5、6缸中某喷油器短路errors -> stop engineDfp_InjVlvBnk2Afaultpath bank2-specific4、5、6缸中某喷油器短路errors -> stop engineDfp_InjVlvBnk2Bfaultpath bank2-specific4、5、6缸中某喷油器断路warnings -> stop engineDfp_InjVlvBnk2Bfaultpath bank2-specific4、5、6缸中某喷油器断路warnings -> stop engineDfp_InjVlvBnk2Bfaultpath bank2-specific4、5、6缸中某喷油器断路warnings -> stop engineDfp_InjVlvBnk2Bfaultpath bank2-specific4、5、6缸中某喷油器断路warnings -> stop engineDfp_InjVlvChipACY33X 系统配置错误Dfp_InjVlvChipACY33X 系统配置错误Dfp_InjVlvChipACY33X 系统配置错误Dfp_InjVlvChipACY33X 系统配置错误Dfp_InjVlvChipBCY33X 系统内部程序错误Dfp_InjVlvChipBCY33X 系统内部程序错误Dfp_InjVlvChipBCY33X 系统内部程序错误Dfp_InjVlvChipBCY33X 系统内部程序错误faultpath Chip-specificerrors -> stop enginefaultpath Chip-specificerrors -> stop enginefaultpath Chip-specificerrors -> stop enginefaultpath Chip-specificerrors -> stop enginefaultpath Chip-specificerrors -> stop enginefaultpath Chip-specificerrors -> stop enginefaultpath Chip-specificerrors -> stop enginefaultpath Chip-specificerrors -> stop engine11Weichai5233517FC5711Weichai5233517FC5711Weichai5233517FC5712Weichai5233517FC571103Weichai5233527FC58Weichai5233527FC5804Weichai5233527FC5811Weichai5233527FC5811Weichai5233537FC5911Weichai5233537FC5911Weichai5233537FC5912Weichai5233537FC59110304120203041202WeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichai52335233523352335233555233555233555233557FC5A7FC5A7FC5A7FC5A7FC5B7FC5B7FC5B7FC5BWeichai6510028BDfp_InjVlvCyl1A喷油器1短路Dfp_InjVlvCyl1A喷油器1短路Dfp_InjVlvCyl1A喷油器1短路Dfp_InjVlvCyl1A喷油器1短路Dfp_InjVlvCyl1B喷油器1开路Dfp_InjVlvCyl1B喷油器1开路Dfp_InjVlvCyl1B喷油器1开路Dfp_InjVlvCyl1B喷油器1开路Dfp_InjVlvCyl2A喷油器2短路Dfp_InjVlvCyl2A喷油器2短路Dfp_InjVlvCyl2A喷油器2短路Dfp_InjVlvCyl2A喷油器2短路Dfp_InjVlvCyl2B喷油器2开路Dfp_InjVlvCyl2B喷油器2开路Dfp_InjVlvCyl2B喷油器2开路Dfp_InjVlvCyl2B喷油器2开路Dfp_InjVlvCyl3A喷油器3短路Dfp_InjVlvCyl3A喷油器3短路Dfp_InjVlvCyl3A喷油器3短路Dfp_InjVlvCyl3A喷油器3短路Dfp_InjVlvCyl3B喷油器3开路Dfp_InjVlvCyl3B喷油器3开路Weichai6510028BWeichai6510028BWeichai6510028BWeichaiWeichaiWeichaiWeichaiWeichai6516516516516520028B0028B0028B0028B0028CWeichai6520028CWeichai6520028CWeichai6520028CWeichaiWeichaiWeichaiWeichaiWeichai6526526526526530028C0028C0028C0028C0028DWeichai6530028DWeichai6530028DWeichai6530028DWeichaiWeichai6536530028D0028Dfaultpath cylinder1-specific errors -> stopenginefaultpath cylinder1-specific errors -> stopenginefaultpath cylinder1-specific errors -> stopenginefaultpath cylinder1-specific errors -> stopenginefaultpath cylinder1-specific warningsfaultpath cylinder1-specific warningsfaultpath cylinder1-specific warningsfaultpath cylinder1-specific warningsfaultpath cylinder2-specific errors -> stopenginefaultpath cylinder2-specific errors -> stopenginefaultpath cylinder2-specific errors -> stopenginefaultpath cylinder2-specific errors -> stopenginefaultpath cylinder2-specific warningsfaultpath cylinder2-specific warningsfaultpath cylinder2-specific warningsfaultpath cylinder2-specific warningsfaultpath cylinder3-specific errors -> stopenginefaultpath cylinder3-specific errors -> stopenginefaultpath cylinder3-specific errors -> stopenginefaultpath cylinder3-specific errors -> stopenginefaultpath cylinder3-specific warningsfaultpath cylinder3-specific warnings03110811111112110311081111111211031108111111WeichaiWeichaiWeichai65365360028D0028D0028EDfp_InjVlvCyl3B喷油器3开路Dfp_InjVlvCyl3B喷油器3开路Dfp_InjVlvCyl4A喷油器4短路Dfp_InjVlvCyl4A喷油器4短路Dfp_InjVlvCyl4A喷油器4短路Dfp_InjVlvCyl4A喷油器4短路Dfp_InjVlvCyl4B喷油器4开路Dfp_InjVlvCyl4B喷油器4开路Dfp_InjVlvCyl4B喷油器4开路Dfp_InjVlvCyl4B喷油器4开路Dfp_InjVlvCyl5A喷油器5短路Dfp_InjVlvCyl5A喷油器5短路Dfp_InjVlvCyl5A喷油器5短路Dfp_InjVlvCyl5A喷油器5短路Dfp_InjVlvCyl5B喷油器5开路Dfp_InjVlvCyl5B喷油器5开路Dfp_InjVlvCyl5B喷油器5开路Dfp_InjVlvCyl5B喷油器5开路Dfp_InjVlvCyl6A喷油器6短路Dfp_InjVlvCyl6A喷油器6短路Dfp_InjVlvCyl6A喷油器6短路Dfp_InjVlvCyl6A喷油器6短路Weichai60028EWeichai60028EWeichai60028EWeichaiWeichaiWeichaiWeichaiWeichai66666550028E0028E0028E0028E0028FWeichai6550028FWeichai6550028FWeichai6550028FWeichaiWeichaiWeichaiWeichaiWeichai6556556556556560028F0028F0028F0028F00290Weichai65600290Weichai65600290Weichai65600290faultpath cylinder3-specific warningsfaultpath cylinder3-specific warningsfaultpath cylinder4-specific errors -> stopenginefaultpath cylinder4-specific errors -> stopenginefaultpath cylinder4-specific errors -> stopenginefaultpath cylinder4-specific errors -> stopenginefaultpath cylinder4-specific warningsfaultpath cylinder4-specific warningsfaultpath cylinder4-specific warningsfaultpath cylinder4-specific warningsfaultpath cylinder5-specific errors -> stopenginefaultpath cylinder5-specific errors -> stopenginefaultpath cylinder5-specific errors -> stopenginefaultpath cylinder5-specific errors -> stopenginefaultpath cylinder5-specific warningsfaultpath cylinder5-specific warningsfaultpath cylinder5-specific warningsfaultpath cylinder5-specific warningsfaultpath cylinder6-specific errors -> stopenginefaultpath cylinder6-specific errors -> stopenginefaultpath cylinder6-specific errors -> stopenginefaultpath cylinder6-specific errors -> stopengine12110311081111111211031108111111121103110811WeichaiWeichaiWeichaiWeichaiWeichai65665665665652022600290002900029000290Dfp_InjVlvCyl6B喷油器6开路Dfp_InjVlvCyl6B喷油器6开路Dfp_InjVlvCyl6B喷油器6开路Dfp_InjVlvCyl6B喷油器6开路Dfp_InjVlvNumMinInj正常工作的气缸数小于最小缸数Dfp_InjVlvNumMinInj正常工作的气缸数小于最小缸数Dfp_InjVlvNumMinInj正常工作的气缸数小于最小缸数Dfp_InjVlvNumMinInj正常工作的气缸数小于最小缸数Dfp_MFLvCrCtlModeDfp_MIL故障灯故障Dfp_MIL故障灯故障Dfp_MIL故障灯故障Dfp_MIL故障灯故障Dfp_MRlyCD主继电器2故障Dfp_MRlyCD主继电器2故障Dfp_MSSCD巡航开关故障Dfp_MSSCD巡航开关故障Dfp_MSSCD巡航开关故障Dfp_MnRly1_SCBDfp_MnRly1_SCGfaultpath cylinder6-specific warningsfaultpath cylinder6-specific warningsfaultpath cylinder6-specific warningsfaultpath cylinder6-specific warnings111112117F022Weichai5202267F022Weichai5202267F022Weichai5202267F022Weichai596002WeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichai12131213121312131485148552022752022752022726342634004BD004BD004BD004BD005CD005CD7F0237F0237F02300A4A00A4Afaultpath -The minimalnumber of injections was12not reached-> stop enginefaultpath -The minimalnumber of injections was255not reached-> stop enginefaultpath -The minimalnumber of injections was255not reached-> stop enginefaultpath -The minimalnumber of injections was255not reached-> stop enginefault path for cruisecontrol actuating deviceevaluation errorPower Stage fault statusfor MILPower Stage fault statusfor MILPower Stage fault statusfor MILPower Stage fault statusfor MILerror path for main relay 2error path for main relay 202030412020304error path of multiple state03switcherror path of multiple state04switcherror path of multiple state02switch03error path for main relay 1error path for main relay 104Weichai5234207FC9CDfp_MontrWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichai63912311235981001001001001001751751751751750027F004CF004D300062000620006200062000000000000000000AF000AF000AF000AF000AFDfp_NetMngCANAOffDfp_NetMngCANBOffDfp_NetMngCANCOffDfp_OLSCD机油液位传感器故障Dfp_OLSCD机油液位传感器故障Dfp_OLSCD机油液位传感器故障Dfp_OLSCD机油液位传感器故障Dfp_OPSCD机油压力传感器故障Dfp_OPSCD机油压力传感器故障Dfp_OPSCD机油压力传感器故障Dfp_OPSCD机油压力传感器故障Dfp_OPSCD1Dfp_OTSCD机油温度传感器故障Dfp_OTSCD机油温度传感器故障Dfp_OTSCD机油温度传感器故障Dfp_OTSCD机油温度传感器故障Dfp_OTSCD1Dfp_OvRMonDfp_OvRMonSigADfp_PCRGvnrDvtMaxDfp_PCRGvnrDvtMinDfp_PSPCD_Actr电动燃油泵故障Dfp_PSPCD_Actr电动燃油泵故障Dfp_PSPCD_Actr电动燃油泵故障WeichaiWeichai11085202280047F024WeichaiWeichaiWeichaiWeichaiWeichai5202295202305202315202315202317F0257F0267F0277F0277F027the fault path contains thesupervision of thecommunicationbetweenWatchdog of CY310 andthe controller. The path isused to handle thereversible Shut-down ofthe system using theengine coordinatorBusoff in CAN ABusoff in CAN BBusoff in CAN Cerror path for engine oillevel sensorerror path for engine oillevel sensorerror path for engine oillevel sensorerror path for engine oillevel sensorerror path of oil pressuresensorerror path of oil pressuresensorerror path of oil pressuresensorerror path of oil pressuresensorerror path for oil pressuretoo low errorerror path of oiltemperature sensorerror path of oiltemperature sensorerror path of oiltemperature sensorerror path of oiltemperature sensorerror path of oiltemperature sensor forabove normal errorFault path of overrunmonitoringFault path for redundantengine speed calculationin overrun monitoringPermanent governordeviation in PCRPermanent governordeviation in PCRerror path of power stagepre-supply pumperror path of power stagepre-supply pumperror path of power stagepre-supply pump02121212030412020304120217030412021716151517030412WeichaiWeichaiWeichai5202315202329707F0277F028003CADfp_PSPCD_Actr电动燃油泵故障Dfp_RunUpTstDfp_SOPTst冗余断缸测试故障Dfp_SOPTst冗余断缸测试故障Dfp_SOPTst冗余断缸测试故障Dfp_SSpMon1传感器电源1电压超出门槛值Dfp_SSpMon1传感器电源1电压超出门槛值Dfp_SSpMon2传感器电源2电压超出门槛值Dfp_SSpMon2传感器电源2电压超出门槛值Dfp_SSpMon3传感器电源3电压超出门槛值Dfp_SSpMon3传感器电源3电压超出门槛值Dfp_ShOffTstDfp_SysLamp系统灯故障Dfp_SysLamp系统灯故障Dfp_SysLamp系统灯故障Dfp_SysLamp系统灯故障Dfp_T15CDerror path of power stage02pre-supply pumpfaultpath for runup testFault path for test ofredundant shut off pathsduring initializationFault path for test ofredundant shut off pathsduring initializationFault path for test ofredundant shut off pathsduring initializationsensor supply voltage 104sensor supply voltage 103sensor supply voltage 204sensor supply voltage 203sensor supply voltage 304sensor supply voltage 3faultpath for shut off testPower Stage fault statusfor System lampPower Stage fault statusfor System lampPower Stage fault statusfor System lampPower Stage fault statusfor System lamperror path for terminal 15 -contains plausibility error[Sig] of T15fault path for Terminal 50component driver -T50CDTPU monitoringfault path for short circuitto battery for TVA powerstagefault path for short circuitto ground for TVA powerstage20030412022551203Weichai970003CAWeichai970003CA04Weichai10790043703Weichai107900437Weichai108000438Weichai108000438Weichai5236017FD51Weichai5236017FD51WeichaiWeichaiWeichaiWeichaiWeichaiWeichai5202336246246246241587F029002700027000270002700009E1207Weichai104100411Dfp_T50CDDfp_TPUMonDfp_TVACD_MaxWeichaiWeichai5235505202347FD1E7F02A0203Weichai5202347F02ADfp_TVACD_Min04Weichai5202347F02ADfp_TVACD_SigNpl空气节流阀信号不可信Dfp_TVACD_SigNpl空气节流阀信号不可信Dfp_VSSCD1车速1信号不可信Dfp_VSSCD1车速1信号不可信Dfp_VSSCD1车速1信号不可信Dfp_VSSCD1车速1信号不可信Dfp_VSSCD2车速2信号不可信Dfp_VSSCD2车速2信号不可信Dfp_VSSCD2车速2信号不可信Dfp_VSSCD2车速2信号不可信Dfp_VSSCD3车速3信号不可信Dfp_VSSCD3车速3信号不可信Dfp_VSSCD3车速3信号不可信Weichai5202347F02AWeichaiWeichaiWeichaiWeichai84848484000000000000fault path for no load andexcess temparature forTVA power stagefault path for no load andexcess temparature forTVA power stagefault path 1 for vehiclespeed sensingfault path 1 for vehiclespeed sensingfault path 1 for vehiclespeed sensingfault path 1 for vehiclespeed sensingfault path 2 for vehiclespeed sensingfault path 2 for vehiclespeed sensingfault path 2 for vehiclespeed sensingfault path 2 for vehiclespeed sensingfault path 3 for vehiclespeed sensingfault path 3 for vehiclespeed sensingfault path 3 for vehiclespeed sensing120200111202WeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichai162416241624162455552023900658006580065800658002850028500285030412020304127F02FDfp_VarMngCodDsErrorpath for datasetvariant coding,Npl=Requested variant11could not be set,Sig=variant dataset defectErrorpath for datasetvariant coding,Npl=Requested variantcould not be set,Sig=variant dataset defectthe fault path contains thesupervision of the SPI-HandlerPower Stage fault statusfor Warning LampPower Stage fault statusfor Warning LampPower Stage fault statusfor Warning LampPower Stage fault statusfor Warning LampFault path of air conditionpower stageFault path of air conditionpower stage02Weichai5202397F02FDfp_VarMngCodDsWeichai5236007FD50Dfp_WdComDfp_Wrn故障指示灯故障Dfp_Wrn故障指示灯故障Dfp_Wrn故障指示灯故障Dfp_Wrn故障指示灯故障Dfp_ACCDCmpr空调压缩机故障Dfp_ACCDCmpr空调压缩机故障12030412020304WeichaiWeichaiWeichaiWeichaiWeichaiWeichai6246246246241351135100270002700027000270007007WeichaiWeichaiWeichai135113511192007007004A8Dfp_ACCDCmpr空调压缩机故障Dfp_ACCDCmpr空调压缩机故障Dfp_BPACD_ADCBPA信号故障Dfp_BPACD_ADCBPA信号故障Dfp_BPACD_ADCBPA信号故障Dfp_HpTstDfp_MeUnCDNoLoadDfp_MeUnCDNoLoadDfp_MeUnCDSCBatDfp_MeUnCDSCGndDfp_MeUnCD_ADCWeichai1192004A8Weichai1192004A8Fault path of air conditionpower stageFault path of air conditionpower stageerror path of boostpressure actuator currentAD-channelerror path of boostpressure actuator currentAD-channelerror path of boostpressure actuator currentAD-channelHpTsterror path of metering unitPWM-powerstageerror path of metering unitPWM-powerstageerror path of metering unitPWM-powerstageerror path of metering unitPWM-powerstage12020304122005020304WeichaiWeichaiWeichaiWeichaiWeichaiWeichai5202235236155236155236155236155236157F01F7FD5F7FD5F7FD5F7FD5F7FD5Ferror path of metering unit16AD-channelerror path of metering unit18AD-channelerror path of rail pressure00relief valveerror path of rail pressure11relief valveerror path of rail pressure07relief valve03error path of rail pressureerror path of rail pressureerror path RPS offsetmonitoringerror path RPS offsetmonitoring041517Weichai5236157FD5FDfp_MeUnCD_ADCDfp_PRVMon共轨泻压阀打开Dfp_PRVMon共轨泻压阀打开Dfp_PRVMon共轨泻压阀打开Dfp_RailCD轨压传感器故障Dfp_RailCD轨压传感器故障Dfp_RailCDOfsTst轨压传感器电压偏差超限Dfp_RailCDOfsTst轨压传感器电压偏差超限Dfp_RailMeUn0WeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichai5234705234705234701571571571575236137FCCE7FCCE7FCCE0009D0009D0009D0009D7FD5Dfaults for checks in MeUn16controlled modefaults for checks in MeUn15controlled modeWeichai5236137FD5DDfp_RailMeUn1Weichai5236137FD5DDfp_RailMeUn2faults for checks in MeUn17controlled modefaults for checks in MeUn04controlled modeWeichai5236137FD5DDfp_RailMeUn3WeichaiWeichaiWeichaiWeichai5236135236135236135236137FD5D7FD5D7FD5DDfp_RailMeUn4Dfp_RailMeUn6Dfp_RailMeUn77FD5DWeichai5236137FD5DWeichaiWeichaiWeichai520235520235677002A5Weichai677002A5Weichai677002A5Dfp_RailMeUn10faults for checks in MeUn03controlled modefaults for checks in MeUn18controlled modefaults for checks in MeUn02controlled mode07faults for checks in MeUncontrolled mode05Dfp_RailMeUn12Dfp_SSpMon12V12V传感器电源电压故障Dfp_SSpMon12V12V传感器电源电压故障Dfp_StrtCDHS起动电机高端故障Dfp_StrtCDHS起动电机高端故障faults for checks in MeUncontrolled mode12V sensor supply voltage12V sensor supply voltagefault path for short circuitto batery or ground forhigh power stagefault path for short circuitto batery or ground forhigh power stagefault path for short circuitto batery or ground, noload, or excesstemparature for low sidepower stagefault path for short circuitto batery or ground, noload, or excesstemparature for low sidepower stagefault path for short circuitto batery or ground, noload, or excesstemparature for low sidepower stageerror path of over coolanttemperatureerror path of over coolanttemperature0304037F02B7F02B0403Dfp_StrtCDLS起动电机低端故障Weichai677002A5Dfp_StrtCDLS起动电机低端故障04Weichai677002A5Dfp_StrtCDLS起动电机低端故障05WeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichaiWeichai1101105236135202425202415202405202435202435202435202445202440006E0006E7FD5D7F0327F0317F0307F0337F0337F0337F0347F034Dfp_CTSCDOvrTempDfp_CTSCDOvrTempdfp_railmeun8dfp_brk1swterrdfp_brk1swtcrctlrlsdfp_brk1swtcrctllmpdfp_rmtapp1dfp_rmtapp1dfp_rmtapp1dfp_rmtapp2dfp_rmtapp21515130202020304020304WeichaiSDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3222222222242424242424237373723236767675202447F03400122001230022200223001210022100120002200212002163021090023800237002360022700228001930019200191dfp_rmtapp2Accel Pedal Sensor No.1Signal Too lowAccel Pedal Sensor No.1Signal Too highAccel Pedal Sensor No.2Signal Too lowAccel Pedal Sensor No.2Signal Too highAccel Pedal Sensor No.1not closeAccel Pedal Sensor No.2not closeAccel Pedal Sensor No.1not openAccel Pedal Sensor No.2not openBoth Accel Pedal SensorSignal InvalidIdle switch stuck openedIdle switch stuck closedBoost Pressure SensorSignal Too HighBoost Pressure SensorSignal Too LowBoost Pressure SensorPerformance InvalidPTO Accel Pedal SensorSignal Too lowPTO Accel Pedal SensorSignal Too highCommon Rail PressureSensor Signal Too HighCommon Rail PressureSensor Signal Too lowCommon Rail PressureSensor Signal keeping themiddle rangeVehicle System VoltageToo HighVehicle System VoltageToo lowCoolant TemperatureSensor Signal Too HighCoolant TemperatureSensor Signal Too lowFuel Temperature SensorSignal Too HighFuel Temperature SensorSignal Too lowIntake Air TemperatureSensor Signal Too HighP0122P0123P0222P0223P0121P0221P0120P0220P2120P2163P2109P0238P0237P0236P0227P0228P0193P0192P0191022626111114141600563005620011800117001830018200113P0563P0562P0118P0117P0183P0182P0113SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ316151444451312132121212800112022290222801143011420061700337003420038500503005020050101681Intake Air TemperatureSensor Signal Too lowAtom Pressure SensorSignal Too HighAtom Pressure SensorSignal Too lowIMC Volume Signal TooHighIMC Volume Signal TooLowStarter Switch Short toBATTCrank Sensor No PulseCam Sensor No PulseCrank & Cam Sensor NoPulseVehicle Speed SensorFrequency Too HighVehicle Speed SensorInput Open / ShortVehicle Speed SensorSignal InvalidExhaust Brake MV1Output Open Load/Shortto GNDExhaust Brake MV1Output Short to BATTCOM1 output short toBATT TWV1or3or5 outputshort to BATTCOM1 output short toGND TWV1or3or5 outputshort to GNDCOM1 output open loadBoth TWV1 and TWV3and TWV5 open loadCOM2 output short toBATT TWV2or4or6 outputshort to BATTCOM2 output short toGND TWV2or4or6 outputshort to GNDCOM2 output open loadBoth TWV2 and TWV4and TWV6 open loadTWV1 output open loadInjector coil openTWV2 output open loadInjector coil openTWV3 output open loadInjector coil openTWV4 output open loadInjector coil openP0112P2229P2228P1143P1142P0617P0337P0342P0385P0503P0502P0501P168128570168202148P1682P21485702147P21475702146P21465802151P21515802150P21505802149P21495155535600201002050020300206P0201P0205P0203P0206SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ35259002020020400611590020074006297500627SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ37501190780009379797777696861656366627252602293012170121801219010000880030100302003030030400305003060021900100201530TWV5 output open loadInjector coil openTWV6 output open loadInjector coil openCapacitor charge-upcircuit malfunction(insufficient charge)Capacitor charge-upcircuit malfunction(excessive charge)SCV(+) output short toBATT; SCV(-) output shortto BATTSCV(+) output OpenLoad/short to GND ;SCV(-) output OpenLoad/short to GND ; SCVcoil openSupply pump control valve(suction control valve)stuckCommon Rail PressureSensor PerformanceInvalid included fuel leakSupply pump protectionSupply pump exchangeP0202P0204P0611P0200P0629P0627P1190P0093P2293P1217Supply pump malfunctionP1218(insufficient flow)pressure limiter activatedP1219Common rail pressureexceeds upper limitCommon rail pressureexceeds hi upper limitCylinder 1 fuel systemfalureCylinder 2 fuel systemfalureCylinder 3 fuel systemfalureCylinder 4 fuel systemfalureCylinder 5 fuel systemfalureCylinder 6 fuel systemfalureEngine overrunGlow Relay Output Shortto GNDGlow Relay Output OpenLoad/Short to BATTEngine Stop switch stuckclosedP10P0088P0301P0302P0303P0304P0305P0306P0219P01P02P1530SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3639394849410021700234002990167601677000730100100704Coolant Temp. exceedsupper limitBoost Pressure Sensorexceeds upper limitBoost Pressure Sensorexceeds lower limit1st/Rev SW OpenLoad/Short to GND1st/Rev SW Output Shortto BATTCAN1 Node ErrorCAN2 Node ErrorClutch Switch CircuitMalfunction (manualtransmission only)Neutral Switch CircuitMalfunction (manualtransmission only)F/D (Flow Damper) #1activatedF/D (Flow Damper) #2activatedF/D (Flow Damper) #3activatedF/D (Flow Damper) #4activatedF/D (Flow Damper) #5activatedF/D (Flow Damper) #6activatedCan Bus-Line Open FromATCan Bus-Line Open FromABSCan Bus-Line Open FromMETERMain relay diagnostics;Main relay stuck closedCruise SW CircuitMalfunctionQR data is not writtenQR data ErrorQR definition error(Definition concerning QRcorrection is not right)CPU fault; -Watchdog ICfaultCPU fault; -Main CPUfaultcheck sum error - FlashareaP0217P0234P0299P1676P1677U0073U1001P07044700850P0850616563666299932200026300275002690027800266002720010100121001550068601565016020060201601P0263P0275P0269P0278P0266P0272U0101U0121U0155P0686P1565P1602P0602P1601333006070060600601P0607P0606P0601SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ3SDECSC9DFQ318181849290052300522005240256001683Engine Oil PressureP0523Sensor too HighEngine Oil PressureP0522Sensor too LowEngine Oil Pressure DownP0524Coolant Level LowBleeder Brake MV1Output Open Load/Shortto GNDBleeder Brake MV1Output Short to BATTBleeder Brake MV2Output Open Load/Shortto GNDBleeder Brake MV2Output Short to BATTSCV coil shortWater in fuel filter failure燃油过滤器内有水的故障P2560P168329290168401685P1684P168529019016860062A02269P1686P062AP2269FMIDescription FMI描述气隙调整不当说明调整传感器与齿圈的间隙0.8-1.2轮胎或齿圈不正确数据出厂设定或用户自换轮胎尺寸问题传感器极柱短接接地或短路开路短路不正确的齿圈检查传感器接线检查接线短路或搭铁检查接线断路检查传感器信号线与地线之间短路齿圈滑动电线错接调整气隙速度异常（咔哒作响）频率太高气隙调整不当检查间隙过小或齿圈间隙处有铁屑检查ABS线路分错调整传感器与齿圈的间隙0.8-1.2调整传感器与齿圈的间隙0.8-1.2调整传感器与齿圈的间隙0.8-1.2轮胎或齿圈不正确数据出厂设定或用户自换轮胎尺寸问题传感器极柱短接检查传感器接线接地短路开路短路不正确的齿圈检查接线短路或搭铁检查接线断路检查传感器信号线与地线之间短路齿圈滑动电线错接调整气隙速度异常（咔哒作响）检查间隙过小或齿圈间隙处有铁屑检查ABS线路分错调整传感器与齿圈的间隙0.8-1.2调整传感器与齿圈的间隙0.8-1.2频率太高气隙调整不当调整传感器与齿圈的间隙0.8-1.2轮胎或齿圈不正确数据出厂设定或用户自换轮胎尺寸问题传感器极柱短接检查传感器接线接地短路开路短路不正确的齿圈检查接线短路或搭铁检查接线断路检查传感器信号线与地线之间短路齿圈滑动电线错接调整气隙速度异常（咔哒作响）频率太高气隙调整不当检查间隙过小或齿圈间隙处有铁屑检查ABS线路分错调整传感器与齿圈的间隙0.8-1.2调整传感器与齿圈的间隙0.8-1.2调整传感器与齿圈的间隙0.8-1.2轮胎或齿圈不正确数据出厂设定或用户自换轮胎尺寸问题传感器极柱短接检查传感器接线接地短路开路短路不正确的齿圈检查接线短路或搭铁检查接线断路检查传感器信号线与地线之间短路齿圈滑动电线错接检查间隙过小或齿圈间隙处有铁屑检查ABS线路分错调整气隙速度异常（咔哒作响）频率太高 与电源短接，检查接线柱接线柱有断路 接地短路 与电源短接，检查接线柱接线柱有断路 接地短路 与电源短接，检查接线柱接线柱有断路 接地短路 与电源短接，检查接线柱接线柱有断路 接地短路 与电源短接，检查接线柱接线柱有断路 接地短路电压过低或断路检查 WL-接地端检查ABS阀继电器调整传感器与齿圈的间隙0.8-1.2调整传感器与齿圈的间隙0.8-1.2电压过低或断路，检查电源线和接地线电压过低或断路，检查电源线和接地线检查WL-接地 接地短路阀继电器电压过低或断路，检查电源线和接地线制动信号输入端断开或接地短路 不同制动阀，与UBATT短接不同的制动阀，开路不同的制动阀，接地短路UBATT挂车制动阀，与UBATT短接 拖车制动阀，开路 拖车制动阀，与地线短接 警示灯接地SAE J1939 VSC1速度可靠性差 SAE J1939开路或短路 没有接入SAE J1939SAE J1939 ERC_DR暂停 SAE J1939 ERC_ER(_EXR) 暂停SAE J1939 ETC暂停SAE J1939 EEC1暂停 SAE J 1939 ERC_EXR 暂停SAE J1939, internal errorSAE J1939内部错误 超电压EEPROM 轮参数不正确EPROM 校验和电子w/o负载当不能使用诊断仪检查时，滑动检查时间超出调节器阀激活时间所有阀无信号，包括 ABS, 控制阀参数错误无 ABS，无闪码多种可能32V36VV<8V32V36VV<8V32V36VV<8V32V36VV<8V32V36VV<8V检查更换灯泡I< ISI< ISI< ISI< ISI< ISI< ISI< ISI< ISI< ISI< IS0.6V<(Vout/Vc)<1V0.14V<(Vout/Vc)< 0.38VVout/Vc>1VVout/Vc<0.14V0.6V<(Vout/Vc)<1V0.14V<(Vout/Vc)< 0.38VVout/Vc>1VVout/Vc<0.14V6V8VV<2V电压高于正常值（s.c.到蓄电池或开路）l电压低于平常值电压高于平常值电压高于正常值（s.c.到蓄电池或开路）电压低于正常值（s.c.接地） 行驶记录仪看不到时间/日期 发动机从EDC启动模式不可用 无法从EDC得到发动机机油温度EEPROM无法存储日期 EEPROM无法存储时间EEPROM无法存储机油液面 电压高于正常值（s.c.到蓄电池或开路）电压低于正常值（s.c.接地）车身电脑电源或搭铁断路或连接不好；CAN线断路发动机EDC电源或搭铁断路或连接不好；CAN线断路行驶记录仪电源或搭铁断路或连接不好；CAN线断路无ABS电源或搭铁断路或连接不好；CAN线断路无无无信号过强信号太弱没有使用信号与参考信号不一致 信号不可靠检查接线可能接触不良，时断时续检查接线是否短路检查接线是否短路检查接线是否接触不良离合器信号没有通过CAN信号不可靠信号错误信号不可靠 没有信号电压过高电压过低CAN信号错误电压不可靠无效的信号组合无效的信号结合与蓄电池短接离合器信号CAN总线传输错误检查接线可能接触不良，时断时续制动信号线断路或短路检查接线可能接触不良，时断时续没有T15信号电压值超出上限值电压值低于下限值CAN信号错误电压值超出上限门槛值信号不可靠信号不可靠与电源短路接地短路信号过强 信号太弱与蓄电池短接接地短路 与蓄电池短接与蓄电池短接接地短路与蓄电池短接或开路接地短路与蓄电池短接接地短路开路多元信号故障继电器打开过早（启动后未连接）与地短路输出信号电压太高输出信号电压太低与电源短路与地短路与电源短路与电源短路与地短路与电源短路或断路与地短路与电源短路与地短路断路信号故障接地与地短路信号太强 信号太弱CAN 信号故障机油温度信号不可靠未达到最小温度上升信号太强信号太弱CAN信号故障信号太强信号太弱CAN 信号故障信号不可靠信号太强信号太弱信号太强信号太弱 阀打开信号电压太高信号电压太低CAN信号传输错误信号不可信信号电压太高信号电压太低CAN信号传输错误信号电压太高信号电压太低CAN信号传输错误信号不可信信号电压太高信号电压太低信号电压太高信号电压太低控制阀常开要求的压力冲击（在正常的开要求进行压力冲击（在正常的打开压力下放的压力情况下阀没有打开）阀不能正常打开）压力冲击后阀没有打开信号太弱 信号太强硬件故障输出值太高信号电压太高信号电压太低CAN信号错误在受压力冲击后阀不能打开信号电压太高信号电压太低硬件故障输出值太高信号电压太高信号电压太低CAN信号错误冷却液温度信号不可靠信号不可信Minimum Temperature notreached in time未及时达到最低温度 值高于上限轨压值超过上限门槛值值低于下限值太低温度太高没有信号信号错误后备模式没有信号信号错误信号抵消按钮卡死按钮卡死 发动机超速运行Test actuive扭矩被轨压值低于下限门槛值输出值太低温度太高没有信号输出信号错误备用模式没有信号输出信号错误转角信号偏置按钮卡死按钮卡死发动机超速运行测试被激活扭矩被扭矩被扭矩被扭矩被扭矩被扭矩被扭矩被燃油流量高于正偏差上限门槛燃油流量高于正偏差上限门槛值值燃油压力太高导致监控单元关燃油压力太高导致监控单元关闭闭共轨压力太低共轨压力太低共轨压力太高轨压下降斜率高于预测值共轨压力太高轨压下降斜率高于设定值监控单元设定的轨压不可信监控单元设定的轨压不可信燃油系统泄漏或者监控单元关燃油系统泄漏或者监控单元关闭闭开路开路温度太高与电源短路对地短路温度太高与电源短路对地短路喷油器低电压端与与电源短路喷油器低电压端与与电源短路根据实际应用情况喷油器高电压端与地短路标定数据没有对其区分根据实际应用情况喷油器高电压端与地短路标定数据没有对其区分喷油器低电压端与与电源短路喷油器低电压端与与电源短路根据实际应用情况喷油器高电压端与地短路标定数据没有对其区分根据实际应用情况喷油器高电压端与地短路标定数据没有对其区分喷油器低电压端与与电源短路喷油器低电压端与与电源短路根据实际应用情况喷油器高电压端与地短路标定数据没有对其区分根据实际应用情况喷油器高电压端与地短路标定数据没有对其区分喷油器低电压端与与电源短路喷油器低电压端与与电源短路根据实际应用情况喷油器高电压端与地短路标定数据没有对其区分根据实际应用情况喷油器高电压端与地短路标定数据没有对其区分喷油器低电压端与与电源短路喷油器低电压端与与电源短路根据实际应用情况喷油器高电压端与地短路标定数据没有对其区分根据实际应用情况喷油器高电压端与地短路标定数据没有对其区分喷油器低电压端与与电源短路喷油器低电压端与与电源短路根据实际应用情况根据实际应用情况喷油器高电压端与地短路标定数据没有对其区分根据实际应用情况根据实际应用情况开路根据实际应用情况根据实际应用情况根据实际应用情况开路根据实际应用情况根据实际应用情况根据实际应用情况开路根据实际应用情况根据实际应用情况根据实际应用情况开路根据实际应用情况根据实际应用情况根据实际应用情况开路根据实际应用情况根据实际应用情况根据实际应用情况开路根据实际应用情况未达到喷射量短路喷油器高电压端与地短路标定数据没有对其区分根据实际应用情况根据实际应用情况开路根据实际应用情况根据实际应用情况根据实际应用情况开路根据实际应用情况根据实际应用情况根据实际应用情况开路根据实际应用情况根据实际应用情况根据实际应用情况开路根据实际应用情况根据实际应用情况根据实际应用情况开路根据实际应用情况根据实际应用情况根据实际应用情况开路根据实际应用情况短路低电压端与地短路低电压端与地短路根据实际应用情况根据实际应用情况标定数据没有对其区分标定数据没有对其区分短路低端与地短路根据实际应用情况标定数据没有对其区分Internal reset - Clock Loss -Voltage too low解锁-ECU初始化测试模式SPI通讯错误短路低端与地短路根据实际应用情况标定数据没有对其区分内部设置-时间丢失-电压值太低解锁-ECU初始化测试模式SPI通讯错误内部设置-时间丢失-电压值太重新设置-时基丢失-电压值太低低解锁-ECU初始化解锁-ECU初始化测试模式SPI通讯错误Torque LimitationCAN Bus offCAN Bus offCAN Bus offCAN timeoutCAN timeoutCAN timeoutCAN timeoutCJ940 CommunicationfailureRead failureWrite failure测试模式SPI通讯错误扭矩被CAN传输中断CAN传输中断CAN传输中断CAN传输超时CAN传输超时CAN传输超时CAN传输超时CJ940信息错误读写数据功能失效刷写数据功能失效Default Value usedRecovery occurred备用锁定解除Watchdog and Controller not看门狗开关不可信plausibleWatchdog 看门狗Supply Voltage too highSupply Voltage too lowTime deviation betweenSystem and TPUVariant Dataset not validVariant could not be setSPI Communication failureReference Voltage too highReference Voltage too lowTest Impulse ErrorQueue ErrorRecovery occurredRecovery occurredShort to BatteryShort to Ground电源输入太高电源输入太低系统和TPU运行时间不符变量数据设定不合理变量设置功能失效SPI通讯错误电压太高电压太低测试程序错误监控排列错误抑制被解除抑制被解除与电源短路对地短路Injection disabledInjection Time too longSpeed Signal not plausibleSignal too highSignal too low喷油器异常喷射时间太长车速信号不可靠信号电压太高信号电压太低Signal too highSignal too lowSignal too highSignal too low信号电压太高信号电压太低信号电压太高信号电压太低Signal too highSignal too low信号电压太高信号电压太低Supply Voltage CJ940 above供给电源在CJ940之上LimitSupply Voltage CJ940 below供给电源在CJ940之下LimitSignal too high信号电压太高Signal too lowCAN Signal failureSignal not plausible toReference Pressure (Boostor Exhaust)Short to Battery or excesstemperatureShort to Ground信号电压太低CAN信号错误信号不可信与电源短路或温度过高与地短路Open Load开路 CAN Msg. TimeOut error Non-Plausible CAN Msg.Value SRC-High error of ADCreference voltage SRC-Low error of ADCreference voltage Test impulse error ADC queue error Voltage above upper limit Voltage below lower limit airmass ADC raw value >threshold high airmass ADC raw value